Treatment of MTBE Contaminated Water by Means of Granular Activated Carbon (GAC) Adsorption

Document Type : Research Paper

Authors

• Nader Mokhtarani ¹
• Elham Shafiee ²

¹ Assistant Professor, Civil and Environmental Engineering Faculty, Tarbiat Modares University, 1411713116, Tehran, Iran

² MSc. Postgraduate, Civil and Environmental Engineering Faculty, Tarbiat Modares University, 1411713116, Tehran, Iran

Abstract

Nowadays, Producing and using chemical compounds in different industrials has caused environmental pollution. One of these compounds that can bring a widespread pollution in natural resources is Methyl Tert-Butyl Ether (MTBE). This organic compound that is produced in petrochemical industries is used as a substitute to produce lead free gasoline in all over the world. Human exposure to MTBE may cause dizziness, coughing, fever, headaches, vomiting, muscular aches, sleepiness and skin and eye irritation. Concerning the destructive consequences of MTBE on the environment, and human health, clearing polluted resources are vital. The main objective of this study is dedicated to treat MTBE-contaminated waters through adsorption process in the presence of granular activated carbon (GAC). In this study, the effect of pH as well as exposure time on the removal of MTBE from aqueous solution have been examined and finally the efficacies of the process is assessed in terms of organic compounds removal and GAC reusability. According to the results, the adsorption capacity of used activated carbon depends considerably on the PH and reaction time. In this study, after 45 minutes of reaction time at PH of 8 the maximum COD removal efficiency of 62% was achieved. In this research both the Langmuir and Freundlich isotherm model best represented the MTBE adsorption behavior of GAC, having R2 of 92.2% and 84.6%, respectively. Moreover, maximum capacity of adsorption, in optimized condition, was estimated to be 67 mg of COD per each gr of GAC.

Keywords

• MTBE
• Adsorption
• Granular Activated Carbon
• Isotherm

20.1001.1.20086377.1399.13.45.2.5

---

References

1)        ATSDR, Agency for Toxic Substances and Disease Registry (2011). Toxic Substances Portal. Methyl tert-Butyl Ether, ATSDR, Atlanta.

2)        Winterberg, M., Schulte-Korne, E., Peters, U., Nierlich F. (2010)."Methyl Tert-Butyl Ether" in Ullmann's Encyclopedia of Industrial Chemistry, Wiley-VCH, Weinheim.

3)        Richards, S.A. (1999). “Removal of Methyl tert-Butyl Ether (MTBE) over a Solid Acid Catalyst.” MS. Thesis, Lehigh University, Bethlehem, Pennsylvania.

4)        Tawabini, B.,  Makkawi, M. (2017) “Remediation of MTBE-contaminated groundwater by integrated circulation wells and advanced oxidation technologies” Water Science & Technology, 17(4) Available Online 21 June 2017, DOI: 10.2166/ws.2017.128

5)        Nikpey, A., Mortazavi, B., Asilian, H., Khavanin, A., Rezai, A., Soleimanian, A., Kazemian, H. (2005). “Catalytic hydrolysis respectively methyl butyl ether (MTBE) in ground water.” Journal of Chemistry and Chemical Engineering. 24(1), 73-81.

6)        Cheremisinoff, N.P., Rosenfeld, P.E. (2009). Handbook of Pollution Prevention and Cleaner Production, Volume  1., Best Practices in The Petroleum Industry, Elsevier, UK.

7)        Levchuk, I., Bhatnagar, A.,  Silla npää, M. (2014) “Overview of technologies for removal of methyl tert-butyl ether (MTBE) from water,” Sci. Total Environ., 476-477, pp. 415-433.

8)        Krayer, M., Krauss, V., Harremoës Paul, M. (2002). Late lessons from early warnings: the precautionary principle 1896–2000, Chapter 11: MTBE in petrol as a substitute for lead, European Environment Agency, Denmark.

9)        McGarity, T.O. (2004) “MTBE: A Precautionary Tale.” Harvard Environmental Law Review. 28, 281-342.

10)     Mehrazma, I. (2003). Investigation of various aspects of MTBE in gasoline, Majlis Research Center.

11)     Fardi, Gh., Khodadadi, A., Yaghoobi, M. (2010). “Parametric study of the transition from MTBE to the fuel tanks and underground water sources in Tehran.” Iran Water Resources Research. 6(3), 1-11.

12)     Ghadiri, K. (2010). “Removal of Methyl Tertiary Butyl Ether (MTBE) from contaminated water using nano-zeolites and zeolite modified with surfactants.” M. Thesis, University of Medical Sciences, Tehran, Iran.

13)     Lu, J., Xu, F., Cai, W. (2008). “Adsorption of MTBE on nano zeolite composites of selective supports.” Microporous and Mesoporous Materials. 108, 50-55.

14)     Ghadiri, S.K., Nabizadeh, R., Mahvi, A.H., Nasseri, S., Kazemian, H., Mesdaghinia, A.R., Nazmara, Sh. (2010). “Methyl Tert-Butyl Ether Adsorption on Surfactant Modified Natural Zeolites.” Iran. J. Environ. Health. Sci. Eng. 7(3), 241-252.

15)     Inal, F., Yetgin, S., Aksu, G.T., Simsek, S., Sofuoglu, A., Sofuoglu, S.C. (2009). “Activated Carbon Adsorption of Fuel Oxygenates MTBE and ETBE from Water.” Water Air Soil Pollut. 204, 155-163.

16)     Songolzadeh, M., Soleimani, M., Behnood, R. (2013). “Removal of methyl tert-butyl ether (MTBE) from contaminated air and water.” Research Journal of Chemistry and Environment. 17 (1), 76-83.

17)      Dehghani, A., Ebadi, A.,  Shafiei, S.,  Aghaeinejad-Meybodi, A. (2016) “Synthesis, characterization, and application of nano-perfluorooctyl alumina for adsorption of methyl tertiary-butyl ether (MTBE) from aqueous medium” Desalination and Water Treatment, 57(25), 11807-11819

18)      Naser-Sheykhaoleslami, N. S.,  Irani, M., Gholamian, R., Aliabadi, M. (2016) “Removal of MTBE from aqueous solution using natural nanoclays of Iran” Desalination and Water Treatment,  57(56), 27259-27268.

19)     Greenberg, A.E., Clesceri, L.S., Eaton, A.D. (1992). Standard Methods For The Examination of Water and Wastewater, 18th Edition., American Public Health Association(APHA), Amercian Water Works Association(AWWA), Water Environment Federation(WEF), Washington, US.

20)     Faria, P.C.C., Orfao, J.J.M., Pereira, M.F.R. (2007). “Ozonation of aniline promoted by activated carbon.” Chemosphere. 67, 809-815.

21)     Nasiri, A., Mokhtarani, N., Ganjidoost, H. (2012). ”Post Treatment of Composting Leachate by Means of Ozonation and Granular Activated Carbon Adsorption.” Modares Civil Engineering Journal. 12(1), 85-95.

22)     Creek, D., Davidson, J. (2000). Treatment Technologies for Removal of Methyl Tertiary Butyl Ether (MTBE) from Drinking Water, Chapter 4: Granular Activated Carbon, Center for Groundwater Restoration and Protection National Water Research Institute, California.

23)     Ghafar, F. (2004). ”Adsorption Studied of Aromatic Compounds in Aqueous Solution onto Activated Carbons.” MS. Thesis, Universiti Sains Malaysia, Penang, Malaysia.‎

24)     Shukla, S.S., Yu, L.J., Dorris, K.L., Shukla, A. (2005) ”Removal of Nickel from aqueous solutions by sawdust.” Journal of Hazardous Materials. 121, 243-246.

25)     Xiaohui, L. (2010). ”Removal of Humic Substances from Water Using Solar Irradiation and Granular Activated Carbon Adsorption.” phD. Thesis, University College London, London, UK.

26)     Chen, D.Z., Zhang, J. X., Chen, J. M. (2010) ”Adsorption of methyl tert-butyl ether using granular activated carbon: Equilibrium and kinetic analysis.” Int. J. Environ. Sci. Tech. 7 (2), 235-242.

27)     Adebayo, S.B., Tawabini, B.S., Atieh, M.A., Abuilaiwi, F.A., Alfadul, S.  (2016) “Investigating the removal of methyl tertiary butyl ether (MTBE) from water using raw and modified fly ash waste materials” Desalination and Water Treatment, 57, 26307–26312.